When the 2011 Hyundai Sonata came on the scene, there was no doubt it would serve as a dependable ride. And while it has, issues have cropped up over the years. Since the defects were not apparent until later, the manufacturer had to send out recall notices to the owners.
Have there been any engine recalls issued for the 2011 Hyundai Sonata?
Yes, as of August 2020, two engine recalls are on the books due to complaints, such as:
- An obvious gas leak from the fuel pipe
- Knocking noise from the engine bay
- Engine stall or outright failure
Thankfully, we are here to help you better understand the two engine recalls affecting the 2011 Hyundai Sonata. The information we share will help you get the recall repairs done, so you can get back to enjoying your car.
Rapid Connection Rod Wear May Result in Engine Failure
NHTSA Recall ID: 15V568000
Your engine uses small passages to deliver oil to all the moving parts. The oil not only lubricates the parts to keep them moving freely but also cools them down.
Unfortunately, when Hyundai manufactured their naturally aspirated and turbo 2.0L direct-injection engines, metal debris was sometimes left inside after machining. The debris then got stuck in the oil passages for the connecting rods, starving them of oil and accelerating bearing wear.
If allowed to continue, the bearings could fail while driving and cause your engine to stall out.
Depending on the level of damage that exists when you bring your car into the shop, technicians will either perform repairs or replace the engine outright.
To complete repairs, they must clear out the oil passages and replace the connecting rod bearings. If that’s not possible, then they will likely just replace the engine with one that was correctly machined.
Fuel Pump Leak at the Outlet Could Cause Engine Stall
NHTSA Recall ID: 18V934000
On vehicles that had their engine replaced due to blocked oil passages, the service may have resulted in damage to the high-pressure fuel pipe. While maneuvering the engine into place, the fuel pipe may have been crushed, poorly torqued, or simply not aligned properly.
If that happened, fuel could start to leak near the fuel pump outlet and potentially cause a fire. The repairs involve replacement of the affected fuel pipe to stop the leak and resolve the issue in full.
How Do You Address a Recall on a 2011 Hyundai Sonata?
Does your 2011 Sonata have an open recall? To check, head over to the National Highway Traffic Safety Administration (NHTSA) website with your VIN or year, make, and model. Upon inputting that information into the textbox, the system will let you know about any open recalls.
If your vehicle needs repairs, just call 1-855-671-3059 to speak to the Hyundai customer service team. With their help, you will learn where to take your car for repairs and how to move through the next steps.
