The 2011 Ford Edge hauls people, pets, and cargo with ease while staying endlessly dependable. Despite its reliable nature, problems have come up throughout the years. And since the defects were not obvious when the vehicles were sold, the manufacturer had to send out notices well after the fact.
Does the 2011 Ford Edge have any brake recalls on record?
It does not as of August 2020, but there have been many complaints and technical service bulletins addressing:
- Increased brake pedal travel
- Hissing or grunting noise from the booster
- Brake drag that affects drivability
Fortunately, in this article, we are here to share the details of all these 2011 Ford Edge issues and help you find a solution. With that info, you can move forward with the repairs with confidence knowing you are on the right track.
Sync-Equipped Vehicles Can Create a Vehicle Health Report
NHTSA ID: 10090681
If your 2011 Ford Edge has Sync AppLink, it could erroneously create a vehicle health report that turns on the brake system warning light. The warning from this situation does not signal an actual issue, leaving owners in the dark if their vehicle does develop a problem.
Techs can fix the issue by running the vehicle history report with the car in “Park” and with the parking brake off and the engine running. In most cases, that process will turn off the warning light. But if it does not, then techs will need to dig further into the issue to find and fix the problem.
Brake Booster Diaphragm Can Tear Under Normal Use
NHTSA ID: 10054925
Your brake booster makes it much easier to push down your brake pedal and activate the system’s stopping power. This integral device works by letting air into half of the canister to push against the back of the diaphragm.
The resulting atmospheric pressure allows the pedal to push fluid out of the master cylinder and through the lines to each wheel.
Unfortunately, in the 2011 Edge, the diaphragm can end up with a small tear that lets air into the pressurized area. When that happens, you will instantly hear a loud hissing noise and notice that your brake pedal feels spongy and hard to press down.
To fix this 2011 Ford Edge problem, technicians just have to inspect and replace the brake booster if they find a tear in the diaphragm.
Strange Grunting Noise From Brake Booster
NHTSA ID: 10052836
When replacing brake boosters with torn diaphragms, technicians have to bleed the brakes to get the air out of the system. If they do not get out all the air, you might get your car back with a strange problem: a grunting noise coming from the booster.
The noise happens as the system tries to push the air through the lines, which is much harder to move than pressurized fluid. Techs can repair the issue by repeating the brake bleeding process to remove the air in the lines.
Corrosion Near Brake Pads Can Create Drag
NHTSA ID: 10056207
Although the reason is unclear, corrosion can develop between the rear brake pads and their anchor bracket. If that occurs, the buildup of material can create a drag on the brakes that can affect how the vehicle drives.
Technicians have to clean off the corrosion to restore the proper function of the calipers and let them slide back into position with ease.
Before releasing the car back to you, they must manually check that the caliper pistons operate smoothly and fully seat in their original position after letting off the brakes.
How Should You Handle a 2011 Ford Edge Recall?
When you want to check if your 2011 Ford Edge has open recalls, you can do so on the National Highway Traffic Safety Administration’s site. Just type in the year, make, and model or the VIN to see what the system says about your car’s recall status.
Then, if you have any recalls pending, call the Ford customer service line at 1-866-436-7332 to find out how to best address them. The rep will let you know which authorized repair facility to go to and what to expect along the way.
